A Sticky Situation

Advertisements

The weekend was a long-awaited and finally got to Mustang Maniac to get back to work. The plan of action was to finish as much as we could obviously. We started with the HT Leads (high tension leads) or Ignition Leads from the distributor cap to the spark plugs. My original leads were in blue and since then I have changed my mind. I now wanted black ones to match the colour scheme going on under the hood. The HT leads came in a pack and needed to be made to fit the car where I wanted the cables to be routed. Instead of going across the top of the rocker covers where i have the “Powered by Ford” logo it would be partly covered up. So now I wanted them around the front of the covers instead. The leads have the spark plug connections already made and the distributor cap end has to be made to length. To do this properly there is a particular tool that will splice the cable to expose the centre core and then correctly crimp the cables to the fitting.

These are the old wires I used to first start the engine up in the kit form.

Adam advised me that he had a little bling if I wanted it, but it would also serve a very useful purpose. These are the HT lead routing blocks. In effect they hold the cables in place at the side of the engine block and keep the cables neat, the down side is that they just happen to be chrome though. Such a shame – Not!

Anyway, firstly you need to place the leads on the spark plugs and work out where they are going to go and then mark the point where they need to be cut. Leave enough length to allow any loop or safety margin for error. Nothing worse than cutting to short, you can always go shorter.

Once you have cut the leads then you need to slip the rubber boot cap over the wire. As these will be a tight fit a generous spray on the lead and the rubber boor will allow the wire to be pushed into the boot and the end pulled through with some long-nosed pliers to expose the connection.

With the core showing bend the core under the cable to trap onto the fitting and then crimp up.

With the crimp completed pull the boot over the fitting and plug into the correct distributor place or correct firing order. The HT block then screws into place on the rocker cover using the same bolts. Once in place pull through the loop of cable to make it look neat and how you wanted it.

The end result is a great looking set of wires from the front, and the distributor cap is partly hidden by the air filter. But still my OCD wouldn’t allow the cable to be odd and still needed to be neat even though you can’t really see them. But, I know they are there and how they should be.

From the top down it still had to look right.

Next up was the fun bit, I wanted some original stickers back in place under the hood. There was no specific rule of thumb here and each production line and indeed operator would do it how they see fit. So on one car the sticker would in one place and on another it would be somewhere different. A good example of this was the left hand side shock tower, where some of the information sheets were upside down. This meant they read correctly when you look in the engine to service the engine from the fender side, but it was wrong trying to read it from the front. So I went for the right way up as nobody else will be servicing my car apart from Mustang Maniac guys or me.

The stickers came in a pack and I placed them roughly where they should have been, but there is not right or wrong here. I have seen these stickers all over the place, but the couple I had there before the restoration were put back where they came from. there were stickers for the air filter (which wasn’t relevent for my filter), oil filter, battery check, tyre pressures for the glove box etc. Amazing set of stickers that has made a difference.

Once the little bit of fun was finished it was time to complete the dash trim. This had to be screwed into place and use an air powered Dremel type tool to get right into the corners. Can had to be taken not to damage the dash pad going in or coming out with the drill bit still spinning. The black trim looks great and finished the dash area of nicely.

Tip:

Make sure you have a very good fitting screw driver for the screws. If you slip and run forward you will smash into the glass windscreen on the edge and a chance of cracking the glass.

The rear of the car is completed now with the rear handles being fitted to the rear quarter glass winder mechanisms. It seems to finish it of quite nicely.

The outside needed to have the sill mouldings fitted back on. These are held in place by a set of clips pop riveted into the sill. Yogi showed me how to do it and left me to complete the installation on the sill. The front fender would need to be drilled and fitted in place but we ran out of time. I will get some more pics when that part is done, for now you will have to look at the fairly ugly clips.

Moving on to the trunk area now. There is a wire that runs from the loom across the trunk area and under the car to the fuel sender. This was usually held in place by a piece of tape and hidden by the fuel tank. I went a little different and used “P” clips under the securing bolts to hold the cable in place.

I have been thinking about this quite a bit. I have a fantastic polished stainless steel fuel tank that seems a shame to get covered up. So I am thinking about cutting the centre out of the plaid matting and expose the fuel tank just for any shows. when I say gut it out I will only expose the centre part of the fuel tank and cover the nuts and bolts to keep it looking nice and neat. That way the cut out section can then be replaced back onto the fuel tank when not on show or I need to carry things about again.  The matting was brought down from the stores by Adam and we laid it out hoping the creases will drop out soon just like the carpet did.

I will bring that update on the blog as soon as I have decided. Any thoughts out there on whether I should keep it covered or expose just the centre a little?

Error happened.
Share my Content

Stainless Tank

Advertisements

The weeks are dragging now as I can’t wait to get to Mustang Maniac and do more to my car, things that are done now are very visible. I wasn’t sure what was going to happen, but a conversation with Adam and Yogi soon had me focused on the plan of action. The fuel tank I had with the car looked OK, all be it painted a little tired looking, but on full inspection using their internal camera showed some rust around the sender fitting and internal lower seams. To be on the safe side Adam ordered me in a special fuel tank. Not sure what to expect I was sent of to go and pick it up from the stores, oh boy, I was not disappointed. A full polished stainless steel tank was my new bolt in part.

We had to clean up the trunk from light dust to allow the sealer to stick the paint and that in turn would not allow any fumes into the car and stop vibration.

Yogi applied the sealing strip around the edge and we both removed the plastic wrap from the tank. Now at this point we were both very careful as the inner stainless edges of the tank are razor-sharp. The tank was eyed into position and laid onto the sealer strip, the holes were lined up ready for the bolts.

The next step was the filler tube, gaskets, screws, clips and rubber. Previously I had cleaned up the tube, clips and rubber. Adam had a look at my cleaned up rubber tube and chucked it in the bin with a laugh. He was of course right, although it looked pretty good but not brilliant, I would always thinking to myself that it should have been a new one. We fitted the gaskets onto the filler pipe and feed the tube through the rear panel, the rubber was slid up the pipe and the clips roughly fitted. The screws to the back panel were tightened only as a rough guide to stop it turning. The rubber was slid down the pipe to the tank and clamped in place and the pipe screws fully tightened up.

The next job of the day was a slow process but brings this classic Mustang back into the twenty-first century. The task was a specialised stick on matting that will stop any road noise and metal resonance through the car. This particular matting was a special order via Adam, the matting is only a couple of millimetres thick with a very sticky backing. It’s applied like sticky back plastic and heated with a hot air gun to make it easier to mould the mat into place. Yogi showed me the first steps and left me to get on with the task in hand. I found this very therapeutic with instant visible results.

First step make sure the floor holes have the correct plates in place with a little sealer around the edges to stop water ingress.

Second step was to lay the matting. We started from the centre and worked our way out to the edges. Peel a little of the backing and position in place then roll the matting across the surface smoothing down as much as you can.

The hot air gun softens and allows the mat to be pressed into place with the idea to make as much surface contact as possible.

Like laying a complex carpet the pieces should fit together and form a complete coverage, this set of pictures shows my thought process. I started with the front foot wells, bulk head or fire wall up to the insulating matting, then moving onto the rear foot wells. The seat platforms were covered each side and the last parts was the remaining section of the centre tunnel.

Under the rear seat will need to be completed as will the door panels and inside the kick panels, but as the time was getting late (very late), I decided to call it a day (or night) for now. The results so far look amazing. OK, so this matting is not cheap and weighs in a little, but the benefits are well worth it for a weekend cruiser.

Over the last couple of weeks I have been asked what was used to get the effect of paint job. Well you need somebody who knows what he is doing, in this case that was Paul who had patience and dedicated time to complete such a fantastic job. The ingredients he used are listed below, but this does not include the cleaning chemicals, rolls of masking tape, rolls of masking paper or surface wipes etc etc.

The paint colour was Acapulco Blue with a slight twist of metallic, the amounts used are as follows:

Etch Primer – 2lt

Surface Primer – 15lt

Rubberised Underbody Coating – 6lt

Thinned Base Coat – 7lt

Mixed Clear Coat – 8lt

2k Black Primer – 1lt

2k Satin Black – 3lt

2K White Semi Matt – 1/2lt

Matt Clear – 1/2lt

Brushable Seam Sealer – 1lt

As you can see Forty Three litres of sprayable materials in total and one litre of brushable seam sealer.

I was thinking last night that as the trunk now looks so good, there is a very good possibility that I wont put carpet over the whole trunk floor, just so I can see the fuel tank and great the paintwork. The stainless steel fuel tank will visible from behind the car of course. What do you think I should do, carpet or not carpet the trunk?

Error happened.
Share my Content