Gettin’ A Grillin’

The weekend arrived and the anticipation of what awaited me at Mustang Maniac was almost too much to bear. Last week was the dash pad and trunk this week unknown. The first plan of action was the trunk which needed re-gapping. Yogi was at the yard working on a car in the panel shop that needed some welding and a floor. I managed to grab Yogi to show me how the final alignment of the trunk is done. He asked for the half inch socket and ratchet and said undo the two bolts that hold the trunk lid on my side. He did likewise, but he put a tiny pinch on his side after he pushed and pulled it a bit, then done similar my side. He lowered the lid and spot on first time. We tightened the bolts fully and the trunk looks fine again. The only difference this time was that the trunk is sitting slightly proud of the rear quarters. The new rubber seal will need to bed down and the trunk will seat back down correctly again. He made it look so easy! Yogi asked me what I was up to and said I didn’t know as Adam was on a guided tour of the yard and cars with some customers. I said I would like to get the front wings sorted so I could get on with the front end. The half hour that he intended to spend with me lasted the best part of three hours of his own time. Thanks for that Yogi. I learned that the alignment is fine until you put the last few bolts in and it pulls the fender the wrong way. So we had to make adjustments, bend a couple of bits back in place and re-hang the right hand wing. The fenders will need splash guards fitted too, but I didn’t get round to those as the aerial had to be fitted first. The aerial hole in the wing is smaller than the standard Mustang one. I am a little paranoid about leaving the aerial up and some scrotum coming along and bending it over. So I went for a fully retractable version. This will help with the car cover when in storage. Trouble is that the base is not as big and in your face as the original aerial bases. It’s something I can change at a later date though.

My own job to start with after all the gap work was the plenum. This involves in assuming the “Mustang” position, on your back shoulders twisted forty-five degrees, both arms in front of you, head is supported by the T-shift gear selector that fits nicely in your left ear! Yoga experts need to come and watch the way mechanics have to contort their spines in order to see what is going on under these dash areas. The plastic plenum slips over the metal heater fan box and is held in place by four tiny self tap bolts. Easier said than done as the fire wall padding covers the space where the back bolts should go.

plenum1

The two diffuser outlets at the top have a hose that goes up to the windscreen diffusers that was clipped into the dash last week. These replacement hoses are clever in that they have a clip that snaps shut around the openings.

The hoses have to be kept away from the wiper arms. The hoses are tight on the left side up to the dash, but fine on the right hand side.

The fitting of the plenum took a stupid amount of time to fit, mainly because it all done by feel as you can’t get your head in there to see. But once fitted they look quite good. plenum8

Back to the outside now and Adam came down with an arm full of goodies for me. New front grill, front trim and fittings. The grill was a major part I wanted to get on. I worked out that the grill has to be slid into place behind a light bucket then worked carefully around to the centre as the grill sits behind the light fittings. I did it and was quite pleased with myself, up until the point when Adam said I am better of getting the Corral in place first. Dohhhh, I had to take it all back out again. The work requires two hands and concentration not to drag the grill across the paint work. Thus there was not much in the way of photos for the fitting process I’m afraid, there are a few after though of the end result.

There are two visible bolts on the top that hold the centre and hood catch, at the bottom there are four self tap screws that go into the trim. A long extension screw driver with a bolt driver is best her with the magnetic holder making things so easy. The Corral itself has been through the wars, it’s a little tarnished but almost as good as the replacements. But, I wanted something very original from the old car, and there is nothing more original than the identity of car, the Mustang Pony in Corral. I might replace it at a later date I’m not sure yet. For now this is a cross over link between the two cars. Bad choice to keep the old or get a new one? The old one certainly doesn’t look out of place.

grill4

Something missing? Yep the wheels. They were taken of to make it easier to align the fenders gaps up. Here is a clue what I could be doing next week. It could doing the front bumper, or it could be something else, I never really know till I get there.

letters1

All this doesn’t look much as so much time was done on the smaller adjustments to make it look right. But, I have taken some fancy art shots of the corral, just to make me feel better.

Share my Content

Lookin’ After The Pony

The weekend has gone and I have finally got a chance to catch up on the blog. The man cave has been my residence for the last week or so. I have run out of the consumables that I needed to finish the floor pans inside the car. A change of plan that switched my attention to the smaller things I can do in the mean time, the first was the air filter pan which is finished, apart from the final top coat colour what ever that may be. However, I did promise myself not to do any of the pretty things on the car before the basics have been done, such as paint, mechanics, rust etc. But every time I walk into the man cave there is a grill that hangs on the side with this dirty Mustang Corral on it. The grill is no good as the top part has finally broken (when I picked it up), so it won’t be able to be fixed onto the car now. So now I need a nice shiny new one, (never mind then), the original grill has had a poor spray job of black paint from the front which has also gone over the underside of the Corral, but saving the pony Corral was  the most important thing to me as it’s the cars identity after all.

I took the Corral apart and noticed a broken mounting leg or support which was repaired by body filler! The outside of the Corral was cleaned up and the leg was repaired with some JB Weld. The pony was fine, just very dull and no shine so I used a mixture of chrome cleaner and Gibbs Brand to bring it back to life. The results were really good and came out better than I had hoped for, so obviously I am well pleased with it. The full process of the cleaning and repairs I have added a page to the Photo Menu – Body Work – Mustang Corral, or click here for the hyper link, there are over forty photos in total. I did however take a few arty shots of the iconic horse while it was out as I may want to change the header at a later date with my own car and grill. What do you think?

The chrome cleaner was removing the dirt but seemed to be moving the dirt from one end to the other. A different approach was required, the Gibbs Brand cleaned up most of the dirt first and the chrome cleaner done the rest. As some of the metal work was pitted slightly I didn’t want to make it worse by catching the chrome with a cloth and leaving a chromeless spot and so it was treated carefully. The brushed effect wasn’t given any rough stuff either for the very same reason, the Gibbs Brand was the staple cleaner for those areas. I could see that brushed effect would scrape off if abused and ruin the look of the two-tone finish as a few tiny scratches revealed that point after the dirt was removed.

The finished result is a well-groomed pony looking forward to more open road adventures.

finished
finished

Quick Links:

Photo Menu – Bodywork – Mustang Corral click here

Share my Content